Battery installed backwards

cctt · 03-02-2022, 10:13 AM

So yeah I was that guy.
I went out and bought a lithium battery to change the original in my CSC TT 250.
After work I proceeded to do the change and as I was fastening the "negative" side on the new battery I saw a bright red flash coming from the fuse box

. After that I realized that the new battery had the poles reversed in position compared to the original, the new had color caps but I removed them earlier when I unboxed it.
So after being so dumb

I changed the fuse with the spare one and connected the battery right. Bike turned on fine and the battery seems to crank fine.
So I have a couple of questions:

Should I check something else on the bike related to the electrical system,? Today I will be checking the rectifier output.
Will a lithium battery be damaged for that short?
Is there rectifier upgrade in case I need to change mine?

Thanks!

TxTaoRider · 03-02-2022, 10:45 AM

My bet is the fuse was the only damage. Go out and ride.

**JerryHawk250** · 03-02-2022, 10:46 AM

You'll be fine. That's what the fuse is for, to protect the electrical system in case of a short.

tknj99 · 03-02-2022, 11:12 AM

Don't feel bad.. when i was putting the Titan together, the way the battery was situated and where the cables were resting near the terminals, i just connected without paying attention to the polarity at each terminal.. well after blowing several fuses and pulling my hair out trying to trace wiring for a short, i finally realized my error lol and was so happy when i put the last fuse back in and it didn't immediately pop.

cctt · 03-02-2022, 04:36 PM

Quote:

Originally Posted by tknj99

Don't feel bad.. when i was putting the Titan together, the way the battery was situated and where the cables were resting near the terminals, i just connected without paying attention to the polarity at each terminal.. well after blowing several fuses and pulling my hair out trying to trace wiring for a short, i finally realized my error lol and was so happy when i put the last fuse back in and it didn't immediately pop.

If it wasn't for the red flash in the fuse box I would have been totally lost too.

It looks like everything is fine, today I tested some voltages and got:
Bike on, lights off, motor off: 13.2 at battery
Bike on, lights on, motor off: 13.1 at battery
Bike on, lights on, motor on: 13.51 at battery @ idle, 13.82 @ 4.5k rpm throttle blip

After seeing the electrical system layout I was over worrying to much, it seems very basic. Can it be possible to run this platform with the old capacitor trick instead of battery?(Just for knowing)

ExMxer · 03-02-2022, 10:28 PM

Fuse did its job. If you want to know about the old trick to see if it works, well just try it out! Why not?? You are asking questions in doubt over a simple fuse blowing, so you now you wanna know if you can run this ride based on curiosity? Hell, try it out yourself. Tell us all how well it goes for ya......

Don't get ahead of yourself. You come across as a fella asking about an oil change on an old Mustang, and next you have done gone into full engine rebuild wondering if Wesson cooking oil would work for break in...

Baby steps if you are wandering into the unknown

cctt · 03-03-2022, 02:04 PM

Quote:

Originally Posted by ExMxer

Fuse did its job. If you want to know about the old trick to see if it works, well just try it out! Why not?? You are asking questions in doubt over a simple fuse blowing, so you now you wanna know if you can run this ride based on curiosity? Hell, try it out yourself. Tell us all how well it goes for ya......

Don't get ahead of yourself. You come across as a fella asking about an oil change on an old Mustang, and next you have done gone into full engine rebuild wondering if Wesson cooking oil would work for break in...

Baby steps if you are wandering into the unknown

It was just curiosity, without the electric starter my rides will be 50% starting it since my kick skills are very bad

ExMxer · 03-03-2022, 02:53 PM

Quote:

Originally Posted by cctt

It was just curiosity, without the electric starter my rides will be 50% starting it since my kick skills are very bad

My kick skills suck something awful……. Thank God I live on a hill

JFOlivier · 03-03-2022, 06:54 PM

Wondering why the fuse blew, if the battery is connected the right way around it would see the rectifier as an open circuit, the wrong way around and the battery would see a short circuit and blow the fuse. Damage could arise with the high current through the rectifier diodes if the fuse is slow, but if there were no rectifier as soon as you turned on the ignition you would blow your electronic ignition system unless it was reverse polarity protected which I doubt on motor cycles.

03-02-2022, 10:13 AM	#1
cctt Join Date: Mar 2022 Posts: 3	Battery installed backwards So yeah I was that guy. I went out and bought a lithium battery to change the original in my CSC TT 250. After work I proceeded to do the change and as I was fastening the "negative" side on the new battery I saw a bright red flash coming from the fuse box. After that I realized that the new battery had the poles reversed in position compared to the original, the new had color caps but I removed them earlier when I unboxed it. So after being so dumb I changed the fuse with the spare one and connected the battery right. Bike turned on fine and the battery seems to crank fine. So I have a couple of questions: Should I check something else on the bike related to the electrical system,? Today I will be checking the rectifier output. Will a lithium battery be damaged for that short? Is there rectifier upgrade in case I need to change mine? Thanks!
	0

03-02-2022, 10:45 AM	#2
TxTaoRider Join Date: Oct 2020 Location: Flower Mound Texas Posts: 904	My bet is the fuse was the only damage. Go out and ride. __________________ 2021 Tao Tbr7 - "Lucille" Mods so far- Brozz swingarm, 21" front rim (Bridgestone Tw302 rear/Dunlop D606 front tires), Digital gauge cluster, pz30b pumper carb, after market hand guards, aftermarket brake and clutch levers, round fold away mirrors, Fly handlebars shortened slightly, 13t front sprocket 2009 Q-link Legacy 250 1982 Suzuki GS1100ES - "Jolene"
	2

03-02-2022, 10:46 AM	#3
JerryHawk250 Moderator Join Date: Oct 2016 Location: Houma, La. Posts: 11,725	You'll be fine. That's what the fuse is for, to protect the electrical system in case of a short. __________________ 2024 Linhai 300 ATV 4x4 2023 Lifan Lycan 250 Chopper 2023 Venom Evader 2022 Lifan KPX250 2020 Kawasaki Vulcan S (Sold) 2004 Honda ST 1300 2016 Black Hawk 250 (sold) Keihin PE30 carb,125 main,38 slow.Pod filter,ported & decked head 10:1 CR,Direct Ignition Coil,15/40Sprockets,NGK DPR8EIX-9,De-Cat,Dual Oil Cooler,Digital Cluster 2016 Cazador180 XL 2014 Coolster150 JerryHawk250.com My YouTube Channel
	1

03-02-2022, 11:12 AM	#4
tknj99 Join Date: Oct 2020 Location: Central VA Posts: 1,303	Don't feel bad.. when i was putting the Titan together, the way the battery was situated and where the cables were resting near the terminals, i just connected without paying attention to the polarity at each terminal.. well after blowing several fuses and pulling my hair out trying to trace wiring for a short, i finally realized my error lol and was so happy when i put the last fuse back in and it didn't immediately pop. __________________ 2024 Templar 250 2021 Beta 500 RRS 2018 VStrom 1000 XT Former China Bikes: Tao DBX1, Brozz 250, CSC RX4, Titan DLX, Templar X, Storm DLX 150
	2

03-02-2022, 10:28 PM	#6
ExMxer Join Date: Jun 2021 Location: Earth, USA Posts: 196	Fuse did its job. If you want to know about the old trick to see if it works, well just try it out! Why not?? You are asking questions in doubt over a simple fuse blowing, so you now you wanna know if you can run this ride based on curiosity? Hell, try it out yourself. Tell us all how well it goes for ya...... Don't get ahead of yourself. You come across as a fella asking about an oil change on an old Mustang, and next you have done gone into full engine rebuild wondering if Wesson cooking oil would work for break in... Baby steps if you are wandering into the unknown
	1

03-03-2022, 06:54 PM	#9
JFOlivier Join Date: Nov 2020 Location: Northern Neck of Virginia. Posts: 165	Wondering why the fuse blew, if the battery is connected the right way around it would see the rectifier as an open circuit, the wrong way around and the battery would see a short circuit and blow the fuse. Damage could arise with the high current through the rectifier diodes if the fuse is slow, but if there were no rectifier as soon as you turned on the ignition you would blow your electronic ignition system unless it was reverse polarity protected which I doubt on motor cycles.
	0